Sanuvox Quattro-GX4 in-duct air purifier

Skip to the beginning of the images gallery

Details

Inspired by the overwhelming success of the Commercial UV Bio-Wall, the QUATTRO is designed as a Light Commercial / Residential In-Duct UV Air Purifier. The QUATTRO-GX will treat the entire duct at one time, destroying up to 99.99% of the biological and chemical contaminants in the air-stream (Percentage of biological destruction will depend on: size of duct; velocity of the air where the QUATTRO-GX is installed; contaminants to be destroyed; percentage of outside make-up air.)

FOR ODOUR PROBLEMS: In-duct UV air purifier consisting of 4 - 18" T6 high intensity UVC/UVV Germicidal and Oxidation lamps LMPHGXS180 120/230V - 2 UVVsections covered with aluminum. There are no air purifiers on the market that can match the power, intensity and dwell time that the UV Bio-Wall series can deliver.

Commercial / Residential In-Duct UV Air Purifier
Treats the entire duct on one pass
Destroys up to 99.99% of biological contaminants on one pass
Destroys chemicals & biological odours
Installed PARALLEL to the air-stream resulting in greater dwell time between the air and the UV Lamps
1,600 microwatts per/cm2 of UV intensity @ 914mm
Four 457 mm High Intensity 19mm Pure Fused Quartz Lamps
Four Aluminium Anodised Parabolic Reflectors intensify & maximize 360° of UV Energy
Pressure Sensor turns purifier On & Off. Simple installation, just & plug & play
LED Smart Lamp System; Visual Status Display
Four High-Output Electronic Rapid-Start Ballasts
Adjustable Clutch mechanism allows for Reflectors & Lamps to easily extend up to 381 mm to the center of a 762 mm duct
Patented Design & Sanuvox Quality
Recommended Lamp change-out: Commercial: 2 years / Residential: 3 years
CSA deg C/US Certified & CE Approved

The Sanuvox Quattro-GX can be supplied pre-fitted to appropriate ductwork at extra cost on request

Additional Details

Additional Details
Delivery	Dependant on stock availability. Check with us before ordering
Brand	Sanuvox
Warranty	15 year manufacturers ballast warrenty, UVC lamps guaranteed 17000hrs, control electronics 3 year warrenty

Quattro_G-Spec_Sheet-EN-Apr2021_(1).pdf (0.3MB)

Quattro-Complete_Instruction_Manual-EN-Nov2022.pdf (2.7MB)

Useful Articles

Indoor Air Pollution Sources

The EPA in America says most indoor air has 2 - 10 times higher concentrations of harmful pollutants than outdoor air. Some organisations have reported inside pollution levels up to 100 times that found outside. The air indoors is the No. 1 environmental health risk.

Read

27/05/21
Bread Mould: a Bakery Problem with a UV Solution

We can specify and propose an engineered solution which involves Sanuvox ultraviolet air purification equipment and, where required, a prefiltration system.

Read

13/05/21
UV Infection Control

UV Infection Control - A key element to preventing airborne spread of infections in healthcare

Read

08/04/21

View all

Heat Load	Watts	BTU
Average The Room Is A Normal Residential Room, Office, Reception Area Or Similar, Where There Is Not Overly Crowded With People, Computer And Office Equipment.
Above Average There Are Factors That Contribute To Additional Heat Being Generated In The Room E.G. Strong Lighting, Overcrowding With People And Office Equipment, Conservatory Type Room, Or Flat Roofed Room.
High There Are Factors That Contribute To A High Heat Load In The Room. E.G. Commercial Cooking, Much Computer And Server Equipment, Switchgear, Temporary Building With Thin Walls And Flat Room, Plain Glass Conservatory.

Variable	Units	Notes/Guidance
System Airflow	M3/Hr	If you have it in cfm then multiply your cfm value by 1.7 to get m3/hr
Average Combined Pressure Drop Of Filters Of Higher Than F6 Efficiency	Pascals	F8 bag filters pressure drop - typical clean clean to dirty, 160 - 250 Pascals F9 compact filters pressure drop - typical clean to dirty, 160 - 350 Pascals H10 HEPA filter pressure drop - typical clean to dirty, 250 - 600 Pascals 9.8 Pascals = 1 mm wg, & 249 Pascals = 1 inch wg
Carbon Filters Pressure Drop	Pascals	For compact type carbons pressure drop between 100 - 150 Pa Bonded carbon panels typically 150 - 170 Pa Loose granular carbon panels typically 130 Pa
Annual Operational Hours	Hrs/Annum	8760 hours in a year If operating for 5 days a week, excluding public holidays, for 12 hrs/day = 3000 hrs
Cost Of Power	Pence Per Kwh	Huge variance in what different companies pay. heck your last bill to be sure, otherwise put in 10p
Fan Efficiency	(As Decimal Value, Eg 100%=1)	Would typically be around 60%, so if you don’t have specific information use 0.6
Fan Motor Efficiency	(As Decimal Value, Eg 100%=1)	Larger motors should be around 90%, so if you don’t have specific information use 0.9

The Total Average Pressure Drop Over Your Higher Efficiency Filters And/Or Carbon Filters Is;		Pascals
This Pressure Drop Is Costing In Energy Alone	£	Per year
It Is Probable That A Sanuvox In-Duct System Could Break Down The Biological, Chemical And Odourous Contaminants On This Air Flow For Between 16 And 25% Of This Running Cost	£	Lower energy cost estimate of an equivalent Sanuvox system (16%)
	£	Higher energy cost estimate of an equivalent Sanuvox system (25%)

Type Of Building	Kw Range		BTU Range
Sports Centres
Retail Premises
Office Premises
Small Industrial Unit
Medium Industrial Units
Larger Industrial Buildings
School/Community Halls
Churches

Room/building volume	m3
Temperature differential (deltaT °C)	°C

Get in Touch

Sanuvox Quattro-GX4 in-duct air purifier

Give Us a Call

Our Address

Leave a Message

General Enquiries

Technical Enquiries

Postal Address

Email Us